Product ID:4800 MAC'S NON-CHLORINATED BRAKE CLEANER
MSDS Date:06/11/1991
FSC:6850
NIIN:00F051866
MSDS Number: CCFWP

VALVOLINE OIL CO (FORMERLY IN ASHLAND KENTUCKY)

3499 DABNEY DR
LEXINGTON, KY 40512-5000
US

Emergency Phone: 606-264-7000/800-274-5263

Info Phone: 606-264-7000/800-274-5263

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

CARBON DIOXIDE *96-3*

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 1-5%

OSHA PEL 5000 PPM

ACGIH TLV: 9000 MG/CUM

TOLUENE (IARC CARC- GROUP 3) *96-3*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 35-40%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *96-3*

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 25-30%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE * 96-3 *

CAS: 64742-89-8

Fraction By Weight: 25-30%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

CYCLOHEXANE * 96-3 *

CAS: 110-82-7

RTECS: GU6300000

Fraction By Weight: <3.5%

OSHA PEL 1050 MG/CUM

ACGIH TLV: 1030 MG/CUM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
IRRITATION, DERMATITIS. INHALATION: NASAL & RESPIRATORY IRRITATION,
CNS EFFECTS, ASPHYXIATION. INGESTION: GI IRRITATION. ASPIRATION OF
MATERIAL INTO LUNGS MAY CAUSE CHEM ICAL PNEUMONIA, WHICH MAY BE
FATAL. OVEREXPOSURE TO HUMANS MAY CAUSE LIVER ABNORMALITIES & EYE
DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DEFATTING, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUSNESS, VOMITING, DIARRHEA.

First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER. INGESTION:
CALL POISON CONTROL IMMEDIATELY. THIS MATERIAL CONTAINS BOTH
METHANOL & PETROLEUM DISTILLATES. ASPIRATION OF MATERIAL INTO LUNGS
DUE TO VOMIT ING CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
ASPIRATION HAZARD. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR
IF NEEDED. KEEP WARM & QUIET. OBTAIN MEDICAL ATTENTION IN ALL
CASES.

Flash Point Method:TCC
Flash Point:20F
Lower Limits:1.2
Extinguishing Media:REGULAR FOAM/CO2/DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN
POSITIVE PRESSURE DEMAND MODE. NEVER USE WELDING/CUTTING TORCH
ON/NEAR DRUM, EVEN EMPTY, IT CAN IGNITE EXPLOSIVELY.
Unusual Fire/Explosion Hazard:HIGHLY VOLATILE & READILY GIVES OFF
VAPORS WHICH MAY TRAVEL ALONG THE GROUND/BY VENTILATION TO IGNITION
SOURCES & FLASH BACK TO HANDLING SITE.

Spill Release Procedures:SMALL: ABSORB ON PAPER/OTHER ABSORBENT
MATERIALS. LARGE: ELIMINATE IGNITION SOURCES. WEAR PROTECTIVE
EQUIPMENT. STOP AT SOURCE. DIKE & PUMP TO SALVAGE TANKS. REMAINING
LIQUID, TAKE UP W/SAND & OTHER A BSORBENTS & SHOVEL INTO
CONTAINERS. (SEE SUPP)

Handling and Storage Precautions:CONTAINERS MAY BE HAZARDOUS, EVEN WHEN
EMPTIED. EMPTY CONTAINERS MAY RETAIN PRODUCT RESIDUES.

Respiratory Protection:IF WORKPLACE EXPOSURE LIMITS ARE EXCEEDED, WEAR
A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR.
Ventilation:GENERAL/LOCAL EXHAUST VENTILATION TO MAINTAIN TLVS BELOW
EXPOSURE LIMITS.
Protective Gloves:NEOPRENE
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
Supplemental Safety and Health
SPILLS CONT'D: PREVENT RUNOFF TO SEWERS, STREAMS/OTHER BODIES OF WATER.
IF RUN-OFF OCCURS, NOTIFY PROPER AUTHORITIES.

Boiling Pt:B.P. Text:147F
Vapor Pres:97.68
Spec Gravity:0.804-0.806
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR, COLORLESS LIQUID
Percent Volatiles by Volume:>99

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, OPEN FLAME, ELEVATED TEMP.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. FLAMMABLE COMPRESSED GAS

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.